Elon Emails

Why Falcon 1 ran out of liquid oxygen; new launch date

From:
Elon Musk
Date:
December 2005 (Undated in the source. Issued between the November 26 scrub and December 11, 2005, when Spaceflight Now reported its contents; the launch was formally reset to December 19 on December 15.)
To:
SpaceX update mailing list

Partial text. Only these passages were published; [...] marks a gap.

The new launch date is approximately December 20, depending on when the Missile Defense Agency testing is complete. As soon as we have a firm time, it will be posted here. [...] Liquid Oxygen Regarding liquid oxygen (LOX) supplies, we expect to have enough on hand this time to fill the rocket four or five times over. This should account for almost any issue with a particular storage tank as well as an extended hold on the pad. We chartered a C-17 to fly two of our empty high quality LOX containers to Hawaii, sourced another high quality LOX container on Hawaii and put all three on the barge to Kwajalein. In addition, our LOX plant on Kwajalein has been repaired and is producing LOX on island again. Many have asked how we could run out of LOX on a remote tropical island on the last launch attempt. The team tried hard to avoid it, but several issues conspired to create the problem: • The additional month of Merlin testing resulted in additional LOX boil-off on island. Even though it is stored in vacuum jacketed containers, LOX at -300F degrees does not like being on a tropical island at 85F. • The SpaceX LOX plant on island broke down a few weeks prior to launch, which meant we could not top up. • We ordered replacement LOX from Hawaii, but the container quality was poor, so only 20% of what we ordered actually arrived. • Ground winds were unusually high on launch day, which amplifies the boil-off rate significantly, since the Falcon's first stage LOX tank is uninsulated. • All of the above would not have mattered if our final storage tank did not have a small, manual vent valve incorrectly in the open position. Somewhat agonizingly, we were only a few percent away from being full. We just needed a little sip from the last tank. • After a while, we were able to close the vent and fill the vehicle's LOX tanks. However, we use LOX to chill our onboard helium and the absence of ground LOX to do so resulted in the helium heating up and venting back to storage. In the end, we did not have enough LOX to stay filled on the rocket and chill & pressurize the helium. Engine Computer The engine computer reboot anomaly was definitively traced to a ground power problem. Importantly, this would have had no effect on flight, since we switch to vehicle power before the autosequence begins. The reason it cropped up at Kwajalein was that the higher load on the longer umbilical (three times longer than in prior tests) coupled with high temperatures in Kwajalein resulted in increased resistance in the ground umbilical. This was just enough to lower the voltage below minimums and cause an engine computer reset when drawing maximum power. The same max power test was repeated on internal vehicle batteries with no problem at all. This problem has been solved by slightly increasing voltage on the ground umbilical.

About this email

Before the second launch attempt Musk explains how SpaceX ran short of liquid oxygen on a tropical island, what has been shipped in so the rocket can be filled four or five times over, and that the engine computer reboot was a ground power problem that would not have affected flight.

Notes

The source page is a SpaceX media release that embeds this update; it shows no headline or date. Kept here: the opening launch-date paragraph and the first-person 'Liquid Oxygen' and 'Engine Computer' sections. Left out at the [...] and after the end: a third-person recap of the November 26 scrub, a 'SpaceX Launch Overview' section and media viewing logistics, which are press-release boilerplate. Unsigned; Spaceflight Now attributed the same explanations to Musk. The page was read in three passes and the bullet layout is the reader's rendering. Text was retrieved through a page reader, so punctuation and paragraph breaks may differ slightly from the original page.

Where it came from

Published by Musk; attribution single-source.

SpaceX, newsletter. Tags: spacex-update, falcon-1, kwajalein, liquid-oxygen, launch-delay